大孔吸附树脂纯化雷公藤4种有效成分的工艺研究 点击下载
| 论文标题： | 大孔吸附树脂纯化雷公藤4种有效成分的工艺研究 |
| 英文标题： | |
| 中文摘要： | 目的：研究大孔吸附树脂纯化雷公藤药材中4种有效成分的工艺。方法：通过静态吸附及解吸试验，以雷公藤内酯醇、雷公藤内酯甲、雷公藤内酯酮、雷公藤红素的吸附率和解吸率为指标，考察9种型号大孔吸附树脂（ADS-5、ADS-8、HPD100、HPD300、HPD400、HPD450、HPD700、HPD722及HPD750）对雷公藤4种有效成分的纯化性能，筛选最优大孔树脂；以有效成分转移率为考察指标，采用单因素试验考察不同上样方法、拌样树脂占树脂总量比例、树脂-药材质量比、清洗液（种类、用量及清洗流速）、树脂径高比、洗脱液（体积、流速）对吸附的影响，确定最优的洗脱工艺参数条件并进行验证试验。结果：确定HPD722树脂为吸附树脂；树脂径高比为1 ∶ 10，树脂-药材质量比为1 ∶ 2，拌样树脂占树脂总量比例为1 ∶ 10，湿法装柱，拌树脂上样；用12 BV的20％乙醇以12 BV/h的流速清洗，后用12 BV的95％乙醇以6 BV/h的流速洗脱并收集。验证试验结果表明，该工艺对雷公藤4种有效成分的总转移率在90％以上（RSD＝0.99％，n＝3）。结论：该优选纯化工艺稳定可行，适用于雷公藤4种有效成分的纯化。 |
| 英文摘要： | OBJECTIVE： To study the purification technology of 4 active components from Tripterygium wilfordii by macroporous resin. METHODS： The purification abilities of nine macroporous resins（ADS-5， ADS-8， HPD100， HPD300， HPD400， HPD450， HPD700， HPD722 and HPD750） were studied with the adsorption and desorption rates of triptolide， wilforlide， triptonide and tripterine as the index by static adsorption and desorption experiments for 4 active components from T. wilfordii， so as to screen optimal macroporous resins. Using transfer rate of active component as index， single factor test was used to investigate the effects of different sampling method， ratio of mixing sample to total resin quantity， ratio of resin to medicinal material， cleaning solution （type， amount and cleaning flow rate）， diameter- height ratio of resins， eluant （volume， flow rate） on adsorption， so as to determine the optimal elution technology； validation test was also conducted. RESULTS： HPD722 macroporous resin was chosen as adsorption resin； ratio of diameter to height was 1 ∶ 10， resin-medicinal material ratio was 1 ∶ 2， and ratio of mixing sample to total resin quantity was 1 ∶ 10； wet column installing and mixing resin for sample loading were adopted. The macroporous resin was washed with 12 BV 20％ ethanol at the rate of 12 BV/h， and then eluted with 12 BV 95％ ethanol at the rate of 6 BV/h. The verification test results showed that the total transfer rate of 4 active components from T. wilfordii was more than 90％ （RSD＝0.99％， n＝3）. CONCLUSIONS： The optimized technology is stable and feasible， and suitable for the purification of 4 active components from T. wilfordii. |
| 期刊： | 2016年第27卷第16期 |
| 作者： | 王忠震，林兵，昊霞，刘志宏，田振，宋洪涛 |
| 英文作者： | WANG Zhongzhen，LIN Bing，HAO Xia，LIU Zhihong，TIAN Zhen，SONG Hongtao |
| 关键字： | 雷公藤；有效成分；纯化工艺；大孔吸附树脂；吸附率；解吸率；转移率 |
| KEYWORDS： | Tripterygium wilfordii； Active component； Purification technology； Macroporous resin； Adsorption rate； Desorption rate； Transfer rate |
| 总下载数： | 81次 |
| 本日下载数： | 2次 |
| 本月下载数： | 81次 |
| 文件大小： | 619.60Kb |
* 注：未经本站明确许可，任何网站不得非法盗链资源下载连接及抄袭本站原创内容资源!在此感谢您的支持与合作！